|
7 members (+8Rich, Alan Patterson, sprinty, Ian Wegg, Plus Four Guy, CBY, dogmog),
219
guests, and
50
robots. |
|
Key:
Admin,
Global Mod,
Mod
|
|
|
|
|
|
Wales
by Joske Vermeule, September 1
|
|
|
|
|
|
|
Forums39
Topics49,896
Posts837,948
Members9,597
| |
Most Online1,063
Jun 14th, 2026
|
|
|
|
Joined: Jul 2015
Posts: 17
New to Talk Morgan
|
OP
New to Talk Morgan
Joined: Jul 2015
Posts: 17 |
Hi Folks
My 2001 4/4 1.8 Zetec won't start. Just wondering where the fuel pump relay is located?
Thanks
Gordon
|
|
|
|
|
Joined: Aug 2017
Posts: 310 Likes: 9
Learner Plates Off!
|
|
Learner Plates Off!
Joined: Aug 2017
Posts: 310 Likes: 9 |
Hi Darkstar, on my 2002 4/4 under the bonnet on top of the scuttle is an aluminium box with a flip up lid. Left to right is flasher unit, fuel pump, fuel injection and cooling fan. The last 3 are 30-85-86-87-87a. Regards.
1994 +8, BMW Calypso Red.
2002 4/4, 4 seater, BMW Calypso Red.
How do you open the boot?
|
|
|
|
|
Joined: Aug 2017
Posts: 310 Likes: 9
Learner Plates Off!
|
|
Learner Plates Off!
Joined: Aug 2017
Posts: 310 Likes: 9 |
These 3 were Bosch 0 332 014 112 but may have been superseded by 0986AH0602.
1994 +8, BMW Calypso Red.
2002 4/4, 4 seater, BMW Calypso Red.
How do you open the boot?
|
|
|
|
|
Joined: Feb 2016
Posts: 8,695 Likes: 415
Needs to Get Out More!
|
|
Needs to Get Out More!
Joined: Feb 2016
Posts: 8,695 Likes: 415 |
Sorry but those first numbers quoted just refer to generic DC relay pin numbers. If a replacement is required look for 12 volt five pin 40 amp diode protection changeover mini relay. Avoid the cheapest chinese ones, Durite is a good brand as below. ![[Linked Image]](https://www.12voltplanet.co.uk/user/products/large/Mini-Change-Over-Relay-12V-3040A-With-Diode.png)
Richard
2018 Roadster 3.7
1966 Land Rover S2a 88
2024 Royal Enfield Guerrilla 450
1945 Guzzi Airone
|
|
|
|
|
Joined: Jul 2015
Posts: 17
New to Talk Morgan
|
|
OP
New to Talk Morgan
Joined: Jul 2015
Posts: 17 |
Many Thanks,
Flasher is Black Ford, the rest are silver Bosch 0332014112. I swapped the fuel pump relay and the cooling fan one to see if it started, it didn't.
Any suggestions, I haven't run it for a couple of months, spinning fine.
Regards
Gordon
|
|
|
|
|
Joined: Dec 2017
Posts: 2,223 Likes: 183
Talk Morgan Expert
|
|
Talk Morgan Expert
Joined: Dec 2017
Posts: 2,223 Likes: 183 |
Make sure your fuel pump cut off switch hasn't activated.
Bruce
1964 4/4 Series V Comp (Megan)
1994 +8 (Maurice) tis no more
2013 M3W (Olga)
|
|
|
|
|
Joined: Jul 2015
Posts: 17
New to Talk Morgan
|
|
OP
New to Talk Morgan
Joined: Jul 2015
Posts: 17 |
[quote=britmog]"Make sure your fuel pump cut off switch hasn't activated.["
Where will I find that?
Thanks
Gordon
|
|
|
|
|
Joined: Nov 2015
Posts: 8,692 Likes: 498
Just barreling along Needs to Get Out More!
|
|
Just barreling along Needs to Get Out More!
Joined: Nov 2015
Posts: 8,692 Likes: 498 |
Has it been stored on a battery conditioner ? If it's stood for a couple of months and the voltage whilst cranking is low the ECU will often detect this, so it won't 'fire' but will spin over on the starter
Jon M
|
|
|
|
|
Joined: Jul 2007
Posts: 27,831 Likes: 757
Member of the Inner Circle
|
|
Member of the Inner Circle
Joined: Jul 2007
Posts: 27,831 Likes: 757 |
[quote=britmog]"Make sure your fuel pump cut off switch hasn't activated.["
Where will I find that?
Thanks
Gordon It will be on the bulkhead normally on the passenger side above the wiper motor. Press down on the rubber grommet ![[Linked Image]](https://tm-img.com/images/2023/07/26/6758841e7c345951792366c2a0ad8b8f.jpeg)
JohnV6
2022 CX Plus Four
2025 Renault Scenic Alpine etech "Yvette"
|
|
|
|
|
Joined: Jul 2015
Posts: 17
New to Talk Morgan
|
|
OP
New to Talk Morgan
Joined: Jul 2015
Posts: 17 |
Has it been stored on a battery conditioner ? If it's stood for a couple of months and the voltage whilst cranking is low the ECU will often detect this, so it won't 'fire' but will spin over on the starter Yes it has, whats the best approach, to this/ Charge up the batters? Regards Gordon
|
|
|
|
|
